Product ID:11136 RED GLOSS TT-L-50G TYPE 1 NITROCELLULOSE LACQUER
MSDS Date:02/05/1992
FSC:8010
NIIN:00F040553
MSDS Number: BXLVX

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700/800-255-3924

Info Phone: 201-438-3700/800-255-3924

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

MOLYBDATE ORANGE; LEAD CHROMATE MOLYBDATE SULFATE RED

CAS: 12656-85-8

RTECS: QA4660000

Fraction By Weight: 5.74%

OSHA PEL 5 MG/CUM

ACGIH TLV: 5 MG/CUM

SHORT COCONUT ALKYD

Fraction By Weight: 15%

ACGIH TLV: 150 PPM

SHORT OIL ALKYD RESIN SOLUTION

Fraction By Weight: 5%

ACGIH TLV: 150 PPM

WET NITROCELLULOSE, NITROCELLULOSE, NITRATE CELLULOSE,

CAS: 9004-70-0

RTECS: QW0975200

Fraction By Weight: 15%

ACETONE; DIMETHYL KETONE; 2-PROPANONE

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 5%

OSHA PEL 2400 MG/CUM

ACGIH TLV: 750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BUTYL ACETATE (N-BUTYL ACETATE) *95-2*

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ACETATE

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 5%

OSHA PEL 1400 MG/CUM

ACGIH TLV: 1400 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 10%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 5%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 10%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LACQUER THINNER

Fraction By Weight: 5%

ACGIH TLV: 150 PPM

TOLUENE (IARC CARC- GROUP 3) *95-2*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 20%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

Fraction By Weight: 10-15%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-2*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. POTENTIAL CANCER
CAUSING AGENT. INGESTION/INHALATION OF CONCENTRATED MIST CAN CAUSE
LEAD POISONING. ANESTHETIC. MAY CAUSE CNS EFFECTS & DEATH. SMALL
AMOUNTS OF LIQUID ASPIRATED INTO THE RESPIRATORY SYSTEM DURING
INGESTION/FROM VOMITING, MAY CAUSE CHEMICAL PNEUMONIA/PULMONARY
EDEMA.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:DRYING, CRACKING, IRRITATION, RASH, SCALING,
BLISTERING, HEADACHE, DIZZINESS
Medical Cond Aggravated by Exposure:PRE-EXISITING SENSITIVITY TO
SOLVENTS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER.
INGESTION: ASPIRATION HAZARD. DON'T INDUCE VOMITING. KEEP WARM &
QUIET. OBTAI N MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:-4F
Lower Limits:0.9
Upper Limits:19
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:DON'T USE WATER HOSE STREAM, IT MAY SPREAD
FIRE. USE FULL BUNKER GEAR IN FIRE AREA. EVACUATE PERSONNEL. WATER
MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. VAPOR IS >AIR & CAN TRAVEL DISTANCES TO A
IGNITION SOURCE & FLASHBACK. ISOLATE FROM IGNITION SOURCES

Spill Release Procedures:AVOID BREATHING VAPOR, ENSURE ADEQUATE
VENTILATION. AVOID IGNITION SOURCES. ELIMINATE SOURCE OF LEAK
SAFELY BY CLOSING VALVE/PLUGGING HOLE. APPLY INERT ABSORBENT. CLEAN
W/BRISTLE BROOMS/NON SPARKING T OOLS/CLEAN DRY RAGS. USE PROTECTIVE
CLOTHING.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED. PROVIDE RESPIRATORY PROTECTION AGAINST FUMES GENERATED
DURING BURNING. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:ISOLATE FROM HEAT, SPARKS/OPEN FLAMES. DON'T BREATHE
VAPORS/HAVE CONTACT W/EYES/SKIN. PROTECT AGAINST BOTH VAPOR & SPRAY
MIST. CONTACT LENS WEARERS SHOULD CONSULT PROVIDER BEFORE HANDLING.

Respiratory Protection:USE A NIOSH/OSHA APPROVED RESPIRATOR/APPROVED
CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENTILATION IS
RESTRICTED.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP AIR CONTAMINATION
BELOW APPICABLE PEL/TLV LIMITS
Protective Gloves:REQUIRED
Eye Protection:CHEMICAL GOGGLES W/SIDE SHIELDS
Other Protective Equipment:FACE SHIELD, PROTECTIVE CREAMS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. USE NORMAL HYGIENE PRACTICES DURING & AFTER HANDLING
MATERIAL.
Supplemental Safety and Health

Boiling Pt:B.P. Text:83-298F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN RED LIQUID W/TYPICAL SOLVENT ODOR
Percent Volatiles by Volume:71.8

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS & ALKALIES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST/RAGS & REMOVE. FLUSH
W/WATER. DON'T INCINERATE, CUT/WELD EMPTY CONTAINERS. TRANSFER
LIQUID TO CONTAINERS FOR RECOVERY/DISPOSAL. CONTAINS LEAD. DISPOSE
OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. F003
IGNITABILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.